SERVICE UPON RECEIPT - TM-9-2320-386-24-1-10168

TM 9-2320-386-24-1-1

0021 00

UNIT MAINTENANCE INSTRUCTIONS

EXTENDED SERVICE PROGRAM (ESP)

TRUCK, CARGO, 2-1/2-TON, 6X6, M44A3 SERIES TRUCKS (DIESEL)

M35A3, W/O WINCH (NSN 2320-01-383-2047); W/WINCH (NSN 2320-01-383-3850);

M35A3C, W/O WINCH (NSN 2320-01-383-2050); W/WINCH (NSN 2320-01-383-2049);

M36A3, W/O WINCH (NSN 2320-01-383-2048); W/WINCH (NSN 2320-01-383-2046).

SERVICE UPON RECEIPT

GENERAL

a. Upon receipt of a new, used, or reconditioned vehicle, you must determine if the vehicle has been

properly prepared for service. The following steps should be performed:

(1) Inspect all assemblies, subassemblies, and accessories to ensure they are in proper working order.

(2) Secure, clean, lubricate, or adjust as needed.

(3) Check all Basic Issue Items (BII) (TM 9-2320-386-10) to ensure every item is present, in good

condition, and is properly mounted or stowed.

(4) Follow general procedures for all services and inspections given in TM 9-2320-386-10.

b. The operator will assist when performing service upon receipt inspections.

c. Refer to TM 9-2320-386-10 when testing equipment for proper operation.

GENERAL INSPECTION AND SERVICING INSTRUCTIONS

The following steps should be taken while performing general inspections and services:

a. Refer to TM 9-2320-386-10, as well as other sections of this manual when servicing, inspecting, and

lubricating equipment.

WARNING

Skysol-100 mixture is combustible. Use mechanical ventilation whenever

product is used in a confined space, is heated above ambient

temperatures, or is agitated. DO NOT use or store near heat, sparks,

flame, or other ignition sources. Keep container sealed when not in use.

Contact with Skysol-100 may cause skin irritation. Use chemical resistant

gloves. In case of skin contact, remove any contaminated clothing and

wash skin thoroughly with soap and water. Wash contaminated clothing

before reuse. Eye contact may cause irritation, tearing, or blurring of

vision. Use face shield or goggles when eye contact may occur. In case of

eye contact, flush eyes with large amounts of water for at least fifteen (15)

minutes or until irritation subsides. Inhalation may cause irritation to

upper respiratory passages. DO NOT have food or drink in the vicinity.

b. Clean all exterior surfaces coated with rust-preventive compounds with Skysol-100.