UNIT MAINTENANCE - TM-10-5411-233-13-P0171

TM 10-5411-233-13&P

CARGO BED COVER (CBC), TYPE III, 2 1/2 T CARGO TRUCK, LMTV, AND LMTV TRAILER 0017 00

UNIT MAINTENANCE

SIDE WALL REPAIR OF SMALL DENT OR DEPRESSION

THIS SECTION COVERS:

Repair

INITIAL SETUP

Personnel Required: One

Maintenance Level - Unit

Materials/Parts

Methylethylketone (WP 0055, Table 1, Item 3)

Tools and Special Tools

Sandpaper (WP 0055, Table 1, Item 8)

General Mechanic Tool Kit (WP 0041, Table 2,

Wiping Rags (WP 0055, Table 1, Item 6)

Item 1)

Tripod base heat lamp (WP 0041, Table 2, Item 2)

Masking tape (WP 0055, Table 1, Item 5)

Goggles,Industrial (WP 0041, Table 2, Item 3)

Adhesive, Two Part Epoxy (WP 0055, Table 1,

Item 9)

Gloves,Chemical And Oil Protective (WP 0041,

Alodine, Brush (WP 0055, Table 1, Item 12)

Table 2, Item 6)

Sticks, Mixing (WP 0055, Table 1, Item 14)

NOTE

The following procedure covers repair of a depression or small puncture

in any shelter panel skin (depression exceeding 2 square inches (12.9

square cm) or deeper than 0.25 inch (6.4 mm), but not larger than 4

square inches (25.8 square cm) or puncture not larger than 1 square

inch (6.5 square cm).

WARNING

Safety goggles must be worn during repair to protect eyes from flying

metal chips. Failure to wear proper eye protection may result in eye

injury and/or blindness.

WARNING

Two part epoxy adhesive is flammable and toxic and shall be used only

in a well-ventilated area away from all sparks or open flame. Gloves and

safety goggles should be worn during use.

0017 00-1